Potential of Formation Flight for Commercial Aviation: Three Case Studies
Abstract
Formation flight has the potential to significantly reduce aircraft fuel consumption by allowing “follower” aircraft to fly in the aerodynamic wake of “leader” aircraft. However, this requirement for aircraft to be in close proximity for large parts of their journey raises questions about the suitability of flying in formation given the diverse range of existing flights and geographical regions. This paper demonstrates the potential for two-aircraft formation flight for three distinct case studies: long-haul airline, transatlantic airline, and low-cost airline, encompassing a range of typical airline regions and characteristics. The results indicate, even with only minor scheduling alterations, the potential fuel savings could result in saving hundreds of millions of dollars in fuel costs and reducing millions of tonnes of carbon dioxide emissions. An analytical geometric method for calculating all possible combinations of optimal routes is presented. This is coupled with a mixed integer linear program for providing an assignment of aircraft into formation pairs. A number of different key metrics, correlations, and predictive indicators help to determine which flights, airlines, and regions show “good” formation potential. Importantly, this paper also demonstrates these results for a wide range of drag-reduction possibilities and the impact this has on achievable fuel saving.
References
[1] , “The International Air Transport Association (IATA) Annual Review 2018,” 74th Annual General Meeting Sydney, June 2018.
[2] , “Forecast to Grow: Aviation Demand Forecasting in an Era of Demand Uncertainty and Optimism Bias,” Transportation Research, Part E, Vol. 128, July 2019, pp. 400–416. https://doi.org/10.1016/j.tre.2019.06.016
[3] , “The Impacts of Emerging Aviation Trends on Airport Infrastructure,” Journal of Air Transport Management, Vol. 13, No. 1, 2007, pp. 45–52. https://doi.org/10.1016/j.jairtraman.2006.10.004
[4] , “Flightpath 2050 Europe’s Vision for Aviation,” European Commission TR KI-31-11-098-EN-C, 2011. https://doi.org/10.2777/50266
[5] , “Aircraft Optimization for Minimal Environmental Impact,” Journal of Aircraft, Vol. 41, No. 4, 2004, pp. 790–797. https://doi.org/10.2514/1.71
[6] , “Aircraft Cost Index and the Future of Carbon Emissions from Air Travel,” Applied Energy, Vol. 164, Feb. 2016, pp. 553–562. https://doi.org/10.1016/j.apenergy.2015.11.058
[7] , “An Analysis of the Impact of Aircraft Lifecycles on Aviation Emissions Mitigation Policies,” Journal of Air Transport Management, Vol. 28, May 2013, pp. 62–69. https://doi.org/10.1016/j.jairtraman.2012.12.012
[8] , “‘Greener’ Civil Aviation Using Air-to-Air Refuelling–Relating Aircraft Design Efficiency and Tanker Offload Efficiency,” Aeronautical Journal, Vol. 111, No. 1123, 2007, pp. 589–592. https://doi.org/10.1017/S0001924000001858
[9] , “Aerodynamic Considerations of Blended Wing Body Aircraft,” Progress in Aerospace Sciences, Vol. 40, No. 6, 2004, pp. 321–343. https://doi.org/10.1016/j.paerosci.2004.08.001
[10] , “Formation Geometries and Route Optimization for Commercial Formation Flight,” 27th AIAA Applied Aerodynamics Conference, AIAA Paper 2009-3615, 2009. https://doi.org/10.2514/6.2009-3615
[11] , “Military Formation Flight as a Model for Increased Capacity in Civilian Airspace,” 23rd Digital Avionics Systems Conference, Inst. of Electrical and Electronics Engineers, New York, 2004, pp. 1.C.4–1.1–9. https://doi.org/10.1109/DASC.2004.1391244
[12] , “Wake Estimation and Optimal Control for Autonomous Aircraft in Formation Flight,” AIAA Guidance, Navigation, and Control (GNC) Conference, AIAA Paper 2013-4705, 2013. https://doi.org/10.2514/6.2013-4705
[13] , “Aerodynamic Performance of Extended Formation Flight,” Journal of Aircraft, Vol. 48, No. 3, 2011, pp. 855–865. https://doi.org/10.2514/1.C031046
[14] , “Design, Performance and Modeling Considerations for Close Formation Flight,” 23rd Atmospheric Flight Mechanics Conference, AIAA Paper 1998-4343, 1998. https://doi.org/10.2514/6.1998-4343
[15] , “Comparison of Predicted and Measured Formation Flight Interference Effects,” Journal of Aircraft, Vol. 41, No. 2, 2004, pp. 201–207. https://doi.org/10.2514/1.9278
[16] , “An Analytical Study of Drag Reduction in Tight Formation Flight,” AIAA Atmospheric Flight Mechanics Conference and Exhibit, AIAA Paper 2001-4075, 2001. https://doi.org/10.2514/6.2001-4075
[17] , “Flight Test Results of Close Formation Flight for Fuel Savings,” AIAA Atmospheric Flight Mechanics Conference, AIAA Paper 2002-4490, 2002. https://doi.org/10.2514/6.2002-4490
[18] , “F/A-18 Aircraft Performance Benefits Measured During the Autonomous Formation Flight Project,” AIAA Atmospheric Flight Mechanics Conference, AIAA Paper 2002-4491, 2002. https://doi.org/10.2514/6.2002-4491
[19] , “Flight Test Techniques Used to Evaluate Performance Benefits During Formation Flight,” AIAA Atmospheric Flight Mechanics Conference, AIAA Paper 2002-4492, 2002. https://doi.org/10.2514/6.2002-4492
[20] , “Aircraft Route Optimization for Heterogeneous Formation Flight,” 53rd AIAA/ASME/ASCE/AHS/ASC Structures, Structural Dynamics and Materials Conference, AIAA Paper 2012-1524, 2012. https://doi.org/10.2514/6.2012-1524
[21] , “Aircraft Route Optimization for Formation Flight,” Journal of Aircraft, Vol. 51, No. 2, 2014, pp. 490–501. https://doi.org/10.2514/1.C032154
[22] , “Far Field Wake Vortex Evolution of Two Aircraft Formation Flight and Implications on Young Contrails,” Aeronautical Journal, Vol. 124, No. 1275, 2020. https://doi.org/10.1017/aer.2020.3
[23] , “Estimation of Vehicle-Level Fuel Burn Benefits of Aircraft Formation Flight,” Journal of Aircraft, Vol. 55, No. 2, 2017, pp. 1–9. https://doi.org/10.2514/1.C034296
[24] , “Cruise Range in Formation Flight,” Journal of Aircraft, Vol. 54, No. 6, 2017, pp. 2184–2191. https://doi.org/10.2514/1.C034246
[25] , “Autonomous Formation Flight Control System Using In-Flight Sweet-Spot Estimation,” Journal of Guidance, Control, and Dynamics, Vol. 38, No. 6, 2015, pp. 1083–1096. https://doi.org/10.2514/1.G000220
[26] , “Aerodynamics Modeling and Analysis of Close Formation Flight,” Journal of Aircraft, Vol. 54, No. 6, 2017, pp. 2192–2204. https://doi.org/10.2514/1.C034271
[27] , “Wake Sensing and Estimation for Control of Autonomous Aircraft in Formation Flight,” Journal of Guidance, Control, and Dynamics, Vol. 39, No. 1, 2016, pp. 32–41. https://doi.org/10.2514/1.G001138
[28] , “Optimal Routing for Drag-Reducing Formation Flight: A Restricted Case,” Journal of Guidance, Control, and Dynamics, Vol. 39, No. 1, 2016, pp. 173–176. https://doi.org/10.2514/1.G001350
[29] , “Analytic Approach to Optimal Routing for Commercial Formation Flight,” Journal of Guidance, Control, and Dynamics, Vol. 38, No. 10, 2015, pp. 1872–1884. https://doi.org/10.2514/1.G000806
[30] , “A Decentralized Approach to Formation Flight Routing of Long-Haul Commercial Flights,” Journal of Aerospace Engineering, Vol. 233, No. 8, 2019, pp. 2992–3004. https://doi.org/10.1177/0954410018791068
[31] , “Efficient Coordination of Multiple-Aircraft Systems,” 42nd IEEE International Conference on Decision and Control (IEEE Cat. No. 03CH37475), Vol. 1, Inst. of Electrical and Electronics Engineers, New York, 2003, pp. 1035–1040. https://doi.org/10.1109/CDC.2003.1272704
[32] , “Extended Formation Flight at Transonic Speeds,” Journal of Aircraft, Vol. 51, No. 5, 2014, pp. 1501–1510. https://doi.org/10.2514/1.C032385
[33] , “Optimum Spanloads in Formation Flight,” 40th AIAA Aerospace Sciences Meeting and Exhibit, AIAA Paper 2002-0258, 2002. https://doi.org/10.2514/6.2002-258
[34] , “Effect of Trail Aircraft Trim on Optimum Location in Formation Flight,” Journal of Aircraft, Vol. 52, No. 4, 2015, pp. 1201–1213. https://doi.org/10.2514/1.C032865
[35] , “Tight Formation Flight Control,” Journal of Guidance, Control, and Dynamics, Vol. 24, No. 2, 2001, pp. 246–254. https://doi.org/10.2514/2.4735
[36] , “Robust Decentralized Formation Flight Control,” International Journal of Aerospace Engineering, Vol. 2011, Sept. 2011, pp. 1–13. https://doi.org/10.1155/2011/157590
[37] , “Optimal Routing and Assignment for Commercial Formation Flight,” Ph.D. Thesis, Univ. of Bristol, Bristol, England, U.K., 2015. https://doi.org/10.13140/RG.2.2.27277.74721
[38] , “User Manual for the Base of Aircraft Data (BADA) Revision 3.6,” EUROCONTROL Experimental Center, Bretigny, France, 2005, pp. 1–87, https://www.eurocontrol.int/sites/default/files/library/022_BADA_User_Manual.pdf [accessed 7 Sept. 2014].
[39] , “A Geometric Approach to Optimal Routing for Commercial Formation Flight,” AIAA Guidance, Navigation, and Control (GNC) Conference, AIAA Paper 2012-4769, 2012. https://doi.org/10.2514/6.2012-4769
[40] , “Ideal Aerodynamics of Ground Effect and Formation Flight,” Journal of Aircraft, Vol. 42, No. 5, 2005, pp. 1188–1199. https://doi.org/10.2514/1.10942
[41] , “Formation Flight of Birds,” Science, Vol. 168, No. 3934, 1970, pp. 1003–1005. https://doi.org/10.1126/science.168.3934.1003
[42] , “The Fermat-Steiner Problem,” American Mathematical Monthly, Vol. 109, No. 5, 2002, pp. 443–451. https://doi.org/10.1080/00029890.2002.11919871
[43] , “A Generalisation of the Fermat-Torricelli Point,” Mathematical Gazette, Vol. 79, No. 485, 1995, pp. 374–378. https://doi.org/10.2307/3618319
[44] , “A Multi-Stage Centralized Approach to Formation Flight Routing and Assignment of Long-Haul Airline Operations,” Proceedings of the 4th International Conference on Vehicle Technology and Intelligent Transport Systems, Vol. 1, SciTePress, 2018, pp. 47–58. https://doi.org/10.5220/0006661800470058
[45] , Introduction to Flight, 3rd ed.,
McGraw–Hill Series in Aeronautical and Aerospace Engineering , McGraw–Hill, New York, 2000, pp. 310–322.[46] Gurobi Optimization, LLC, “Gurobi Optimizer Reference Manual,” 2019, https://www.gurobi.com/documentation/8.1/refman/index.html [retrieved 30 Sept. 2019].
[47] , “MILP Formulation and Polynomial Time Algorithm for an Aircraft Scheduling Problem,” 42nd IEEE International Conference on Decision and Control (IEEE Cat. No. 03CH37475), Inst. of Electrical and Electronics Engineers, New York, 2003, pp. 5003–5010. https://doi.org/10.1109/CDC.2003.1272423
[48] , “Multiple-Phase Trajectory Optimization for Formation Flight in Civil Aviation,” CEAS Aeronautical Journal, Vol. 10, No. 2, 2019, pp. 453–462. https://doi.org/10.1007/s13272-018-0329-9
[49] , “Accounting for the Effect of Ground Delay on Commercial Formation Flight,” 2014 UKACC International Conference on Control (CONTROL), IEEE, New York, July 2014, pp. 104–109. https://doi.org/10.1109/CONTROL.2014.6915123
[50] , European Air Traffic Management: Principles, Practice and Research, 1st ed., Ashgate, Farnham, England, U.K., 2007, pp. 166–168.
[51] , “On Optimal Routing for Commercial Formation Flight,” AIAA Guidance, Navigation, and Control (GNC) Conference, AIAA Paper 2013-4889, 2013. https://doi.org/10.2514/6.2013-4889
[52] Flight Schedules (online database), OAG Aviation Worldwide, Luton, England, U.K., 2011, https://www.oag.com/airline-schedules-data [retrieved 1 Sept. 2011].
[53] , “The Growth Limits of the Low Cost Carrier Model,” Journal of Air Transport Management, Vol. 21, July 2012, pp. 17–23. https://doi.org/10.1016/j.jairtraman.2011.12.013
[54] FlightStats (online database), Cirium, Portland, OR, 2014, https://www.flightstats.com [retrieved 7 Sept. 2014].
[55] , “The Spatial Configuration of Airline Networks in Europe,” Journal of Air Transport Management, Vol. 9, No. 5, 2003, pp. 309–323. https://doi.org/10.1016/S0969-6997(03)00039-5
[56] , “The Atmospheric Effects of Stratospheric Aircraft: A First Program Report,” NASA TR RP-127, 1992.
[57] Jet Fuel Price Monitor (online database), IATA, Montreal, 2020, https://www.iata.org/en/publications/economics/fuel-monitor [retrieved 7 Sept. 2014].